在進行沼氣發電時，必須控制好沼氣發酵環境，保證發電的效率和質量，因此在使用沼氣發電機組時要注意以下四個方面：

When carrying out biogas power generation, it is necessary to control the biogas fermentation environment well to ensure the efficiency and quality of power generation. Therefore, when using biogas generators, the following four aspects should be noted:

剛采購過來的沼氣發電機組，在運行了50個小時建議進行一次常規保養，因為機組的磨合期的保養至關重要，操作人員必須經常檢查沼氣發電機組進氣管路，防止沼氣泄漏和冷凝水過多而影響供氣。

The newly purchased biogas generator set is recommended to undergo a routine maintenance after 50 hours of operation, as the maintenance during the running in period of the unit is crucial. Operators must regularly check the intake pipeline of the biogas generator set to prevent biogas leakage and excessive condensation water from affecting gas supply.

沼氣發電機工作時應經常巡視、檢查沼氣發電機組的運行情況，沼氣脫硫及穩壓、防爆裝置，另外，為了防止進氣管回火引起沼氣管路發生爆炸，應在沼氣供應管路上安置防回火與防爆裝置，發現問題應及時調整或上報有關領導。

When the biogas generator is working, it should be regularly inspected and checked for the operation of the biogas generator unit, biogas desulfurization, voltage stabilization, and explosion-proof devices. In addition, in order to prevent the explosion of the biogas pipeline caused by the backfire of the intake pipe, anti backfire and explosion-proof devices should be installed on the biogas supply pipeline. If problems are found, they should be adjusted or reported to relevant leaders in a timely manner.

進氣系統：沼氣發電機在運行中，操作人員應隨時掌握負載變化情況并應對沼氣發電機的最大負荷進行限制，在進氣總管上，需加裝一套沼氣一空氣混合器，以調節空燃比和混合氣進氣量。

Air intake system: During the operation of the biogas generator, the operator should constantly monitor the load changes and limit the maximum load of the biogas generator. A biogas air mixer should be installed on the intake manifold to adjust the air-fuel ratio and the amount of mixed gas intake.

發動機：沼氣的燃燒速度很慢，所以對沼氣發動機有較高的要求。沼氣發電機的過濾裝置應定期清洗。

Engine: The combustion speed of biogas is very slow, so there are high requirements for biogas engines. The filtration device of the biogas generator should be cleaned regularly.

調速系統：沼氣發電機組沼氣進氣壓力不得低于1.8kPa，沼氣發動機的運行場合是和發電機一起以用電設備為負荷進行運轉，為了確保發電機正常發電，沼氣發動機上的調速系統必不可少。

Speed control system: The biogas inlet pressure of the biogas generator set shall not be lower than 1.8kPa. The operation of the biogas engine is carried out together with the generator under the load of electrical equipment. In order to ensure the normal power generation of the generator, the speed control system on the biogas engine is essential.

本文來自：生物質氣發電機組更多的內容請點擊：http://www.dgtmcnc.com我們將會為您提問的問題提供一個滿意的服務，歡迎您的來電！

This article is from: Biomass gas generator set. For more content, please click: http://www.dgtmcnc.com We will provide satisfactory service for the questions you ask. Welcome to call us!