Diesel generator set uses diesel as fuel, while gasoline generator set uses gasoline as fuel. As the name implies, biogas generator set uses biogas as fuel. What are the advantages of biogas generator set using biogas as fuel? 

沼氣發電機組是 將"空氣和沼氣"的混合物在氣缸內壓縮，用火花塞使其燃燒，通過火塞的往復運動得到動力，然后連接發電機發電。與傳統發電機相比，它具有三方面優勢：

The biogas generator set compresses the mixture of "air and biogas" in the cylinder, burns it with spark plugs, gets power through the reciprocating motion of the spark plugs, and then connects the generator to generate electricity. Compared with traditional generators, it has three advantages:

①不需要輔助燃料油及其供給設備。

① Auxiliary fuel oil and its supply equipment are not required.

②在操作系統上，其操作比傳統的發電機更為簡單實用。

② In the operating system, its operation is more simple and practical than the traditional generator.

③發電機組價格較低。

③ The price of generator set is low.

沼氣發電機技術本身提供的是清潔能源，不僅解決了沼氣工程中的環境問題、消耗了大量廢棄物、保護了環境、減少了溫室氣體的排放，而且變廢為寶，產生了大量的熱能和電能，符合能源再循環利用的環保理念，同時也帶來巨大的經濟效益。

The biogas generator technology itself provides clean energy, which not only solves the environmental problems in biogas projects, consumes a lot of waste, protects the environment, and reduces greenhouse gas emissions, but also turns waste into treasure, generating a lot of heat and electricity, which conforms to the environmental protection concept of energy recycling, and also brings huge economic benefits.

使用沼氣發電機組要注意以下事項：

Pay attention to the following matters when using biogas generator set:

1.沼氣脫硫脫水一定要做好，務必使用高效工業型脫硫劑，并且要及時更換。目前市面上非常好的氧化鐵脫硫劑，其硫容都在15%左右。處理養殖場沼氣，脫硫劑使用壽命在1500小時左右，到期一定要更換。

1. Methane desulfurization and dehydration must be done well, and efficient industrial desulfurizer must be used and replaced in time. At present, the sulfur capacity of very good iron oxide desulfurizers on the market is about 15%. The service life of desulfurizer for biogas treatment in the breeding farm is about 1500 hours, and the desulfurizer must be replaced when it expires.

2.務必使用沼氣發動機專用油，專用油比普通油粘度高，并且可以吸收沼氣中的硫，這樣可以有效防止渦輪增壓器軸的腐蝕。

2. Make sure to use the special oil for biogas engine. The special oil has a higher viscosity than the ordinary oil and can absorb the sulfur in the biogas, which can effectively prevent the corrosion of the turbocharger shaft.

3.機油更換周期不得超過400小時。即使是專用油，若不按時更換，油質粘度降低，變臟，會導致渦輪增壓器過油不暢，終在高轉速下會加速磨損。

3. The oil change cycle shall not exceed 400 hours. Even if the special oil is not replaced on time, the viscosity of the oil will decrease and become dirty, which will lead to poor oil flow of the turbocharger and accelerated wear at high speeds.

4.沼氣發電機組每次開機后，不要馬上合閘帶負載。因為機油循環到渦輪增壓器需要一定時間。在機油還沒有到增壓器油管時，突然加負載，同樣會導致增壓器的軸，頁片等因缺少潤滑而磨損。

4. Do not switch on the biogas generator with load immediately after each startup. Because it takes some time for the oil to circulate to the turbocharger. When the oil has not yet reached the supercharger oil pipe, sudden loading will also cause the supercharger shaft, leaf, etc. to wear due to lack of lubrication.

以上就是為大家介紹的有關沼氣發電機組的詳細的介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以專業的態度,為您提供服務http://www.dgtmcnc.com

The above is a detailed introduction to the biogas generator set, and I hope it will be helpful to you. If you have any questions, please contact us. We will provide you with professional services http://www.dgtmcnc.com